Fuel System
Last updated
Last updated
C17's Fuel Supply System is designed to provide an uninterrupted flow of fuel under all conditions, attitudes, and altitudes encountered in normal operations. The system consists of four Main Wing tanks, one Extended Range Tank (ER Variant modeled), eight + four boost pumps, four tank transfer pumps, a jettison system, Aerial Refueling valves and all associated indicators.
This rendition of the C17 (ER Variant) Features a total of five fuel tanks:
Two Outboard wing fuel tanks (No. 1 and No. 4), with a capacity of 37,915 lbs each.
Two Inboard wing fuel tanks (No. 2 and No. 3), with a capacity of 52,481 lbs each.
One Extended Range fuel Bladder, with a capacity of 64,433 lbs
Total fuel capacity is therefore 245,226lbs
Fuel is automatically transferred from the ER Tank into the Inboard tanks, and then to the engines. The ER tank has four electrical boost pumps to increase fuel flow outboard from the tank.
After ER tank is depleted completely, fuel will flow out from all four tanks and into the engines, each aided by its boost pump. However, the engines can operate normally without any fuel pumps by a combination of gravity feed and suction feed from the engines.
Fuel capacities and system overview can be seen on the Electronic Flight Bag, Fuel Page.
The fuel panel is located on the overhead panel of the aircraft, right above the Engine Panel and next to the Electrical Panel.
Fuel Dump Valves, L and R: Used for Fuel Dumping, INOP on initial release, see notes below.
L Ground Refuel: INOP. These valves are used to pump fuel from ground to the tanks given the elevation of the wings during single-point refueling, resulting in the "Moose sounds". This is not necessary on MSFS.
A/R AMP ORIDE: INOP
A/R READY: INOP
A/R Left Master: Master Left Aerial Refueling Pump. Opens the AR Slipway and turns on flow of fuel towards the fuel tanks during AAR Operations.
Separation Var: INOP
A/R Door Status Light: Turns on if Aerial Refueling door is unlocked/opened.
Scavange Pump Switch: INOP
A/R Right Master: Master Right Aerial Refueling Pump. Opens the AR Slipway and turns on flow of fuel towards the fuel tanks during AAR Operations.
Main Drain: INOP
R Ground Refuel: INOP. These valves are used to pump fuel from ground to the tanks given the elevation of the wings during single-point refueling, resulting in the "Moose sounds". This is not necessary on MSFS.
HI LVL TEST: INOP
Fill Valves (x4): Provide pressure into fuel tanks for Crossfeed and Refueling operations. INOP on initial release, see notes below.
XFER Valves (x4): Provide pressure out from fuel tanks for Crossfeed and Refueling operations. INOP on initial release, see notes below.
ER Pumps (x4): Provide additional pressure to fuel flowing outwards from the ER Tank. If pumps are off, the fuel will continue flowing due to gravity.
Tank Quantity Indicator (x4): Provides a continuous digital reading to the nearest 100 pounds of fuel of each associated tank. This is, other than the EFB, the only display of fuel quantity per tank on the aircraft.
Crossfeed Valve (x4): Controls the associated crossfeed valve for fuel transfer operations.
Forward/Aft Fuel Boost Pumps (x4 of each): Provide additional fuel pressure to each associated tank. If pumps are off, the fuel will continue flowing due to gravity feed and suction feed.
Engine 1/2/3/4 Shutoff Valve: Control fuel to the respective engine. Closing the valve will shut down the engine due to fuel starvation.
Fuel Qty Fuel Selector: INOP
Additional to the overhead displays, a Total Fuel Indicator is located in between the two pilot MFDs. It provides a continuous display of total fuel quantity, equal to the sum of fuel available on all tanks, including the ER Tanks in pounds.
The LOW amber alert lights up when fuel quantity is under 16,000 pounds. Additionally, Master Caution and Low Fuel WAP will illuminate.
Fuel Crossfeeding and Dumping are not supported on initial release. However, this will be added shortly after in an update. This will also add functionality to Fuel Dump, Fill, XFER and XFEED valves on the overhead panel.
Aerial Refueling will be supported by 3rd party addons such as the upcoming Aerial Refueling Pro by Miltech Simulations. The AR Slipway door can be opened by pressing the A/R MASTER Button (L or R), or through the EFB Services tab.
